Abstract
In wind energy systems, high voltage gain and high power-based forward converters are mainly used for switched-mode power supplies. However, due to the wide range of load usage in grid systems, the reliability and power loss in forward converter-based system performance became crucial. Many earlier researches are conducted to validate the performance of forward converters in renewable resources. But, effective improvement is not achieved for wind applications. Thus, in this paper, the novel grey wolf-based boosting intelligent frame (GWbBIF) control algorithm is proposed in forward converter switching controls. The gain of the controller and duty cycle of the converter is tuned by the proposed control approach. Consequently, the power loss from the wind transformer is optimized by the proposed grey wolf fitness function. The implementation of this research has been done on the MATLAB/Simulink platform. The simulation outcomes of the proposed system are compared with various conventional techniques in terms of total harmonic distortion (THD), power loss, stability, error, driving circuit, etc. While compared with the other methods, the proposed methods effectively show the optimal performance of forward converter in wind system by reduced power loss and improved reliability that is considered as the significant aspects while estimating the entire system.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
Data availability
Enquiries about data availability should be directed to the authors.
References
Abbas G, Asad MU, Gu J, Alelyani S et al (2021) Multivariable unconstrained pattern search method for optimizing digital PID controllers applied to isolated forward converter. Energies 14(1):77. https://doi.org/10.3390/en14010077
Abualigah LMQ (2019) Feature selection and enhanced krill herd algorithm for text document clustering. Springer, Berlin. https://doi.org/10.1007/978-3-030-10674-4
Abualigah L (2021) Group search optimizer: a nature-inspired meta-heuristic optimization algorithm with its results, variants, and applications. Neural Comput Appl 33(7):2949–2972. https://doi.org/10.1007/s00521-020-05107-y
Abualigah L, Diabat A (2021) Advances in sine cosine algorithm: a comprehensive survey. Artif Intell Rev 54:2567–2608. https://doi.org/10.1007/s10462-020-09909-3
Abualigah LMQ, Hanandeh ES (2015) Applying genetic algorithms to information retrieval using vector space model. Int J Comput Appl Eng Sci 5(1):19. https://doi.org/10.5121/ijcsea.2015.5102
Abualigah LM, Khader AT (2017) Unsupervised text feature selection technique based on hybrid particle swarm optimization algorithm with genetic operators for the text clustering. J Supercomput 73(11):4773–4795. https://doi.org/10.1007/s11227-017-2046-2
Abualigah LM, Khader AT, Hanandeh ES et al (2017) A novel hybridization strategy for krill herd algorithm applied to clustering techniques. Appl Soft Comput 60:423–435. https://doi.org/10.1016/j.asoc.2017.06.059
Abualigah LM, Khader AT, Hanandeh ES (2018a) A combination of objective functions and hybrid krill herd algorithm for text document clustering analysis. Eng Appl Artif Intell 73:111–125. https://doi.org/10.1016/j.engappai.2018.05.003
Abualigah LM, Khader AT, Hanandeh ES (2018b) A new feature selection method to improve the document clustering using particle swarm optimization algorithm. J Comput Sci 25:456–466. https://doi.org/10.1016/j.jocs.2017.07.018
Abualigah LM, Khader AT, Hanandeh ES (2018c) Hybrid clustering analysis using improved krill herd algorithm. Appl Intell 48(11):4047–4071. https://doi.org/10.1007/s10489-018-1190-6
Abualigah L, Yousri D, Abd Elaziz M et al (2021) Aquila optimizer: a novel meta-heuristic optimization algorithm. Comput Ind Eng 157:107250. https://doi.org/10.1016/j.cie.2021.107250
Alshinwan M, Abualigah L, Shehab M et al (2021) Dragonfly algorithm: a comprehensive survey of its results, variants, and applications. Multimed Tools Appl 80:14979–15016. https://doi.org/10.1007/s11042-020-10255-3
Aseem K, Kumar SS (2021) Hybrid k-means grasshopper optimization algorithm based FOPID controller with feed forward DC–DC converter for solar-wind generating system. J Ambient Intell Humaniz Comput. https://doi.org/10.1007/s12652-021-03173-1
Başoğlu ME (2020) Forward converter-based distributed global maximum power point tracking in partial shading conditions. SN Appl Sci 2(2):248. https://doi.org/10.1007/s42452-020-2027-6
Biswas PP, Suganthan PN, Mallipeddi R et al (2020) Multi-objective optimal power flow solutions using a constraint handling technique of evolutionary algorithms. Soft Comput 24:2999–3023. https://doi.org/10.1007/s00500-019-04077-1
Chai R, Savvaris A, Tsourdos A, Chai S (2017) Multi-objective trajectory optimization of space manoeuvre vehicle using adaptive differential evolution and modified game theory. Acta Astronaut 136:273–280. https://doi.org/10.1016/j.actaastro.2017.02.023
Chai R, Tsourdos A, Savvaris A et al (2019) Real-time reentry trajectory planning of hypersonic vehicles: a two-step strategy incorporating fuzzy multiobjective transcription and deep neural network. IEEE Trans Ind Electron 67(8):6904–6915. https://doi.org/10.1109/TIE.2019.2939934
Chai R, Tsourdos A, Savvaris A et al (2020) Design and implementation of deep neural network-based control for automatic parking maneuver process. IEEE Trans Neural Netw Learn Syst. https://doi.org/10.1109/TNNLS.2020.3042120
Chen L, Gao R, Bian Y, Di H (2021) Elliptic entropy of uncertain random variables with application to portfolio selection. Soft Comput 25(3):1925–1939. https://doi.org/10.1007/s00500-020-05266-z
Durgadevi S, Umamaheswari MG (2019) Analysis and design of single-phase power factor corrector with genetic algorithm and adaptive neuro-fuzzy-based sliding mode controller using DC–DC SEPIC. Neural Comput Appl 31(10):6129–6140. https://doi.org/10.1007/s00521-018-3424-2
Ettappan M, Vimala V, Ramesh S et al (2020) Optimal reactive power dispatch for real power loss minimization and voltage stability enhancement using Artificial Bee Colony Algorithm. Microprocess Microsyst 76:103085. https://doi.org/10.1016/j.micpro.2020.103085
Fang J, Deng H, Goetz SM (2020) Grid impedance estimation through grid-forming power converters. IEEE Trans Power Electron 36(2):2094–2104. https://doi.org/10.1109/TPEL.2020.3010874
Gao Y, Yang T, Dragičević T et al (2020) Optimal filter design for power converters regulated by FCS-MPC in the MEA. IEEE Trans Power Electron 36(3):3258–3268. https://doi.org/10.1109/TPEL.2020.3017862
Gruner VF, Horn TP, Schmitz L et al (2020) Forward-based high step-up DC–DC converter with input current sharing and output filter reduction: design, modeling, and control. J Control Autom Electr Syst 31(1):21–30. https://doi.org/10.1007/s40313-019-00540-4
Habib S, Khan MM, Abbas F et al (2020) Contemporary trends in power electronics converters for charging solutions of electric vehicles. CSEE J Power Energy Syst 6(4):911–929. https://doi.org/10.17775/CSEEJPES.2019.02700
Kaur M, Narang N (2020) An integrated optimization technique for optimal power flow solution. Soft Comput 24:10865–10882. https://doi.org/10.1007/s00500-019-04590-3
Kim MH, Lee SH, Lee BS et al (2019) Double-ended active-clamp forward converter with low DC offset current of transformer. IEEE Trans Ind Electron 67(2):1036–1047. https://doi.org/10.1109/TIE.2019.2898605
Kou L, Liu C, Cai G, Zhang Z (2020) Fault diagnosis for power electronics converters based on deep feedforward network and wavelet compression. Electr Power Syst Res 185:106370. https://doi.org/10.1016/j.epsr.2020.106370
Li K, Videt A, Idir N et al (2020) Accurate measurement of dynamic on-state resistances of GaN devices under reverse and forward conduction in high frequency power converter. IEEE Trans Power Electron 35(9):9652–9662. https://doi.org/10.1109/TPEL.2019.2961604
Lin JY, Lee SY, Ting CY, Syu FC (2018) Active-clamp forward converter with lossless-snubber on secondary-side. IEEE Trans Power Electron 34(8):7650–7661. https://doi.org/10.1109/TPEL.2018.2879721
Liu K, Yang Z, Tang X, Cao W (2020) Automotive battery equalizers based on joint switched-capacitor and buck-boost converters. IEEE Trans Veh Technol 69(11):12716–12724. https://doi.org/10.1109/TVT.2020.3019347
Meng T, Ben H, Song Y, Li C (2017) Analysis and design of an input-series two-transistor forward converter for high-input voltage multiple-output applications. IEEE Trans Ind Electron 65(1):270–279. https://doi.org/10.1109/TIE.2017.2716913
Muthukumaran E, Kalyani S (2021) Development of smart controller for demand side management in smart grid using reactive power optimization. Soft Comput 25:1581–1594. https://doi.org/10.1007/s00500-020-05246-3
Peyghami S, Blaabjerg F, Palensky P (2020a) Incorporating power electronic converters reliability into modern power system reliability analysis. IEEE J Emerg Sel Top Power Electron. https://doi.org/10.1109/JESTPE.2020.2967216
Peyghami S, Wang Z, Blaabjerg F (2020b) A guideline for reliability prediction in power electronic converters. IEEE Trans Power Electron 35(10):10958–10968. https://doi.org/10.1109/TPEL.2020.2981933
Premkumar M, Jangir P, Kumar BS et al (2021) A new arithmetic optimization algorithm for solving real-world multiobjective CEC-2021 constrained optimization problems: diversity analysis and validations. IEEE Access 9:84263–84295. https://doi.org/10.1109/ACCESS.2021.3085529
Rashidi N, Wang Q, Burgos R et al (2020) Multi-objective design and optimization of power electronics converters with uncertainty quantification—part I: parametric uncertainty. IEEE Trans Power Electron 36(2):1463–1474. https://doi.org/10.1109/TPEL.2020.3005456
Ravikumar S, Vennila H, Deepak R (2020) Hybrid power generation system with total harmonic distortion minimization using improved rider optimization algorithm: analysis on converters. J Power Sources 459:228025. https://doi.org/10.1016/j.jpowsour.2020.228025
Saadatmand S, Shamsi P, Ferdowsi M (2020) The heuristic dynamic programming approach in boost converters. In: 2020 IEEE Texas power and energy conference (TPEC), IEEE. https://doi.org/10.1109/TPEC48276.2020.9042517
Sanam J (2020) Optimization of planning cost of radial distribution networks at different loads with the optimal placement of distribution STATCOM using differential evolution algorithm. Soft Comput 24:13269–13284. https://doi.org/10.1007/s00500-020-04739-5
Soltanzadeh K (2020) Zero-current transition single-ended forward converter. IET Power Electron 13(6):1227–1235
Stenglein E, Scheder A, Kuebrich D et al (2019) New experimental verification of transformer core saturation occurring in forward converters due to remanence flux de. In: PCIM Europe 2019; international exhibition and conference for power electronics, intelligent motion, renewable energy and energy management, VDE
Tashakor N, Li Z, Goetz SM (2020) A generic scheduling algorithm for low-frequency switching in modular multilevel converters with parallel functionality. IEEE Trans Power Electron 36(3):2852–2863. https://doi.org/10.1109/TPEL.2020.3018168
Wang X, Huang Q, Zhang B et al (2021) Z-domain modeling of peak current mode control for full-bridge DC–DC buck converters. J Power Electron 21(1):27–37. https://doi.org/10.1007/s43236-020-00157-w
Xiao Q, Chen L, Xie M, Wang C (2020) Optimal contract design in sustainable supply chain: interactive impacts of fairness concern and overconfidence. J Oper Res Soc. https://doi.org/10.1080/01605682.2020.1727784
Xiao C, Liu Z, Zhang T, Zhang X (2021) Deep learning method for fault detection of wind turbine converter. Appl Sci 11(3):1280. https://doi.org/10.3390/app11031280
Xu C, Ma Q, Xu P, Wang N (2020) Closed-loop gate drive for single-ended forward converter to reduce conducted EMI. IEEE Access 8:123746–123755. https://doi.org/10.1109/ACCESS.2020.3005239
Yan H, Zhao W, Buticchi G, Gerada C (2021) Active thermal control for modular power converters in multi-phase permanent magnet synchronous motor drive system. IEEE Access 9:7054–7063. https://doi.org/10.1109/ACCESS.2021.3049293
Zeng J, He Y, Lan Z et al (2020) Optimal control of DAB converter backflow power based on phase-shifting strategy. Soft Comput 24:6031–6038. https://doi.org/10.1007/s00500-020-04715-z
Zhang X, Nguyen B, Ferencz A et al (2019) A 12-or 48-V input, 0.9-V output active-clamp forward converter power block for servers and datacenters. IEEE Trans Power Electron 35(2):1721–1731. https://doi.org/10.1109/TPEL.2019.2923981
Zhang B, Wang M, Su W (2020) Reliability analysis of power systems integrated with high-penetration of power converters. IEEE Trans Power Syst 36(3):1998–2009. https://doi.org/10.1109/TPWRS.2020.3032579
Acknowledgements
None.
Funding
The authors have not disclosed any funding.
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
Conflict of interest
The authors declare that they have no potential conflict of interest.
Ethical approval
All applicable institutional and/or national guidelines for the care and use of animals were followed.
Informed consent
For this type of study formal consent is not required.
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
Springer Nature or its licensor holds exclusive rights to this article under a publishing agreement with the author(s) or other rightsholder(s); author self-archiving of the accepted manuscript version of this article is solely governed by the terms of such publishing agreement and applicable law.
About this article
Cite this article
Patil, P.R., Tanavade, S. & Dinesh, M.N. Analysis of power loss in forward converter transformer using a novel machine learning-based optimization framework. Soft Comput 27, 3733–3749 (2023). https://doi.org/10.1007/s00500-022-07491-0
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00500-022-07491-0