Abstract
Majority of underwater robots utilize single propeller thrusters for navigation. A disadvantage of using a single-shaft propeller thruster is that the thrust force generated from a single propeller for reverse and forward thrust is asymmetric due to the disturbed flow caused by the thruster’s body which may reduce thruster efficiency. Moreover, measurement procedures to precisely calculate propeller’s rotation speed were also not available. To address these problems, this paper proposes a dual-shaft magnetic coupling-driven propeller thruster for underwater robot, equipped with sensors for measuring propeller’s rotational speed. Numerical studies and experimental results on the position and orientation control of the proposed thruster are presented. Detail comparison of the rotational speed, thrust force and duty ratio between numerical calculation and actual experimental measurement results show the effectiveness of the proposed thruster. This paper also demonstrated that by using the proposed thruster, the control performance of an underwater robot can be improved significantly compared to commercially available thruster. The ability to determine propeller rotation directions is also a major advantage of this work.
Similar content being viewed by others
References
Yuh J, Gonugunta KV (1993) Learning control of underwater robotic vehicles. Proceedings of the IEEE International Conference on Robotics and Automation 2:106–111
Yoerger DR, Cooke JG, Slotine J-JE (1990) The influence of thruster dynamics on underwater vehicle behavior and their incorporation into control system design. IEEE J Ocean Eng 15(3):167–178
Zhang M, Yang L, Wang Y, Duan Q, Liu X (2009), Development and experiment of an underwater vehicle test-bed controlled by rudders and thrusters. In: Proceedings of the IEEE international conference on robotics and biomimetics (ROBIO), pp1633–1638
Allen B, Stokey R, Austin T, Forrester N, Goldsborough R, Purcell M, von Alt C (1997) REMUS: a small low cost AUV; system description, field trials and performance results, Proceedings of the IEEE Oceans 97. New Orleans, USA, pp 994–1000
Sagara S, Tamura M, Yatoh T, Shibuya K (2006) Digital RAC for underwater vehicle-manipulator systems considering singular configuration. Artif Life Robot 10(2):106–111
Sagara S, Yatoh T, Shimozawa T (2010) Digital RAC with a disturbance observer for underwater vehicle-manipulator systems. Artif Life Robot 15(3):270–274
Kawano K, Shimozawa T, Sagara S (2012) A master-slave control system for a semi-autonomous underwater vehicle-manipulator system. Artif Life Robot 16(4):465–468
Author information
Authors and Affiliations
Corresponding author
About this article
Cite this article
Bin Ambar, R., Sagara, S. & Yamaguchi, T. Development of a dual-shaft propeller thruster equipped with rotational speed sensor for UVMS control. Artif Life Robotics 18, 241–247 (2013). https://doi.org/10.1007/s10015-013-0124-y
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10015-013-0124-y