Abstract
Wide bandgap GaN-based HEMTs have shown great potential as key components in various power electronic systems but still face challenges in the pursuit of devices with stable operation capability especially in harsh environments. Here, we report a high-performance double heterojunction (DH) based AlGaN/GaN HEMT by incorporating a decreasing-Al-composition (DAC) graded AlGaN back barrier (BB) beneath the GaN channel. Thanks to the improved electron confinement enabled by graded BB, the DHHEMT exhibits significantly improved on-state drain current density and off-state breakdown voltage compared with a single heterojunction (SH) based HEMT. More intriguingly, with an additional SiNx passivation layer, the surface states of the DH-HEMTs can be effectively suppressed, leading to an almost constant off-state leakage current and negligible gate contact degradation across the temperature range from 25° C to 150° C. These results highlight the superiority and reliability of the proposed graded AlGaN BB to boost device characteristics for applications under high temperatures and harsh conditions.
Similar content being viewed by others
References
Zhang H, Huang C, Song K, et al. Compositionally graded III-nitride alloys: building blocks for efficient ultraviolet optoelectronics and power electronics. Rep Prog Phys, 2021, 84: 044401
Huang C, Zhang H, Sun H. Ultraviolet optoelectronic devices based on AlGaN-SiC platform: towards monolithic photonics integration system. Nano Energy, 2020, 77: 105149
Zhong Y, Zhang J, Wu S, et al. A review on the GaN-on-Si power electronic devices. Fundamental Res, 2022, 2: 462–475
Sun Y, Zhang H, Yang L, et al. Correlation between electrical performance and gate width of GaN-based HEMTs. IEEE Electron Dev Lett, 2022, 43: 1199–1202
Zhang H, Sun Y, Song K, et al. Demonstration of AlGaN/GaN HEMTs on vicinal sapphire substrates with large misoriented angles. Appl Phys Lett, 2021, 119: 072104
Zhang H, Liang F, Song K, et al. Demonstration of AlGaN/GaN-based ultraviolet phototransistor with a record high responsivity over 3.6 × 107 A/W. Appl Phys Lett, 2021, 118: 242105
Nela L, Ma J, Erine C, et al. Multi-channel nanowire devices for efficient power conversion. Nat Electron, 2021, 4: 284–290
Yang J Y, Yeom M J, Lee J, et al. Reconfigurable radio-frequency high-electron mobility transistors via ferroelectric-based gallium nitride heterostructure. Adv Elect Mater, 2022, 8: 2101406
Zhou F, Xu W, Ren F, et al. 1.2 kV/25 A normally off P-N junction/AlGaN/GaN HEMTs with nanosecond switching characteristics and robust overvoltage capability. IEEE Trans Power Electron, 2022, 37: 26–30
Nela L, Xiao M, Zhang Y, et al. A perspective on multi-channel technology for the next-generation of GaN power devices. Appl Phys Lett, 2022, 120: 190501
Cui P, Jia M, Chen H, et al. InAlN/GaN HEMT on Si with fmax = 270 GHz. IEEE Trans Electron Dev, 2021, 68: 994–999
Yang L, Hou B, Jia F, et al. The DC performance and RF characteristics of GaN-based HEMTs improvement using graded AlGaN back barrier and Fe/C Co-doped buffer. IEEE Trans Electron Dev, 2022, 69: 4170–4174
Yu H, Parvais B, Peralagu U, et al. Back barrier trapping induced resistance dispersion in GaN HEMT: mechanism, modeling, and solutions. In: Proceedings of International Electron Devices Meeting (IEDM), 2022
Lee J H, Lisesivdin S B, Lee J H, et al. High figure-of-merit (V 2BR /RON) AlGaN/GaN power HEMT with periodically C-doped GaN buffer and AlGaN back barrier. IEEE J Electron Dev Soc, 2018, 6: 1179–1186
He L, Li L, Zheng Y, et al. The influence of Al composition in AlGaN back barrier layer on leakage current and dynamic RON characteristics of AlGaN/GaN HEMTs. Phys Status Solidi A, 2017, 214: 1600824
Hamza K H, Nirmal D, Fletcher A S A, et al. Enhanced drain current and cut off frequency in AlGaN/GaN HEMT with BGaN back barrier. Mater Sci Eng-B, 2022, 284: 115863
Zhang Y, Guo R, Xu S, et al. High-performance high electron mobility transistors with GaN/InGaN composite channel and superlattice back barrier. Appl Phys Lett, 2019, 115: 072105
Kim J G, Kang S H, Janicki L, et al. Growth of AlGaN/GaN heterostructure with lattice-matched AlIn(Ga)N back barrier. Solid-State Electron, 2019, 152: 24–28
Malmros A, Gamarra P, Thorsell M, et al. Impact of channel thickness on the large-signal performance in InAlGaN/AlN/GaN HEMTs with an AlGaN back barrier. IEEE Trans Electron Dev, 2018, 66: 364–371
Han T, Zhao H, Han L, et al. Investigation into the carrier distribution and energy-band profile in AlGaN/GaN heterostructures with a graded AlGaN buffer. Semicond Sci Technol, 2018, 33: 115018
Hájek F, Hospodková A, Hubík P, et al. Transport properties of AlGaN/GaN HEMT structures with back barrier: impact of dislocation density and improved design. Semicond Sci Technol, 2021, 36: 075016
Liu X, Wang H Y, Chiu H C, et al. Analysis of the back-barrier effect in AlGaN/GaN high electron mobility transistor on free-standing GaN substrates. J Alloys Compd, 2020, 814: 152293
Zhang W, Li X, Zhang J, et al. Overcoming the poor crystal quality and DC characteristics of AlGaN/GaN/AlGaN double-heterostructure high electron mobility transistors. Phys Status Solidi A, 2016, 213: 2203–2207
Wang J, You H, Guo H, et al. Do all screw dislocations cause leakage in GaN-based devices? Appl Phys Lett, 2020, 116: 062104
Besendörfer S, Meissner E, Medjdoub F, et al. The impact of dislocations on AlGaN/GaN Schottky diodes and on gate failure of high electron mobility transistors. Sci Rep, 2020, 10: 17252
Divya P, Kumar A, Lee W H. Effects of SiNX passivation on GaN-HEMT DC characteristics. Mater Sci Semicond Process, 2022, 148: 106716
Lv Y, Lin Z, Corrigan T D, et al. Extraction of AlGaN/GaN heterostructure Schottky diode barrier heights from forward current-voltage characteristics. J Appl Phys, 2011, 109: 074512
Vertiatchikh A V, Eastman L F. Effect of the surface and barrier defects on the AlGaN/GaN HEMT low-frequency noise performance. IEEE Electron Dev Lett, 2003, 24: 535–537
Lu H, Yang L, Hou B, et al. AlN/GaN/InGaN coupling-channel HEMTs with steep subthreshold swing of sub-60 mV/decade. Appl Phys Lett, 2022, 120: 173502
Song W, Li Y, Zhang K, et al. Steep subthreshold swing in GaN negative capacitance field-effect transistors. IEEE Trans Electron Dev, 2019, 66: 4148–4150
Liu X, Gu H, Li K, et al. AlGaN/GaN high electron mobility transistors with a low sub-threshold swing on free-standing GaN wafer. AIP Adv, 2017, 7: 095305
Lu X, Ma J, Jiang H, et al. Low trap states in in situ SiNx/AlN/GaN metal-insulator-semiconductor structures grown by metal-organic chemical vapor deposition. Appl Phys Lett, 2014, 105: 102911
Goswami A, Trew R J, Bilbro G L. Modeling of the gate leakage current in AlGaN/GaN HFETs. IEEE Trans Electron Dev, 2014, 61: 1014–1021
Mukherjee J, Chaubey R K, Rawal D S, et al. Analysis of the post-stress recovery of reverse leakage current in GaN HEMTs. Mater Sci Semicond Process, 2022, 137: 106222
Fang T, Wang R, Xing H, et al. Effect of optical phonon scattering on the performance of GaN transistors. IEEE Electron Dev Lett, 2012, 33: 709–711
Xu N, Hao R, Chen F, et al. Gate leakage mechanisms in normally off p-GaN/AlGaN/GaN high electron mobility transistors. Appl Phys Lett, 2018, 113: 152104
Chen Y H, Zhang K, Cao M Y, et al. Study of surface leakage current of AlGaN/GaN high electron mobility transistors. Appl Phys Lett, 2014, 104: 153509
Acknowledgements
This work was supported by National Natural Science Foundation of China (Grant Nos. 52161145404, 61905236, 51961145110), Fundamental Research Funds for the Central Universities (Grant Nos. WK3500000009, WK2100230020), Students’ Innovation and Entrepreneurship Foundation of USTC (Grant No. CY2022X04), and partially carried out at the USTC Center for Micro and Nanoscale Research and Fabrication.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Zhang, H., Sun, Y., Hu, K. et al. Boosted high-temperature electrical characteristics of AlGaN/GaN HEMTs with rationally designed compositionally graded AlGaN back barriers. Sci. China Inf. Sci. 66, 182405 (2023). https://doi.org/10.1007/s11432-022-3694-4
Received:
Revised:
Accepted:
Published:
DOI: https://doi.org/10.1007/s11432-022-3694-4