Abstract
Thermographic phosphors utilize the luminescence properties of doped ceramic materials and can be used to measure surface temperatures as a non-contact temperature measurement method. These phosphor materials are coated onto the object of interest and are excited by a short UV laser pulse, and exhibit a temperature-sensitive exponential decay in emission when their excitation has stopped. This article first explores the temperature dependence of different binders to fabricate a cost-effective two-dimensional temperature measurement method based on lifetime technique under normal supersonic jet impingement. Different phosphor-coated samples by magnesium fluorogermanate thermographic phosphors were analyzed using a spectrometer and a photomultiplier to study the intensity of emitted light and temperatures at discrete points, respectively. Then, a high-speed camera is used to measure the surface temperature distributions. In the end, the phosphor coating on test specimens was installed under a normal supersonic jet to confirm the coating stability, which is essential for the applications as the temperature sensor.
Graphical abstract
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Ali A, Chepyga LM, Khanzada LS, Osvet A, Brabec CJ, Batentschuk M (2020) Novel two-dimensional phosphor thermography by decay-time method using a low frame-rate CMOS camera. Opt Lasers Eng 128:106010. https://doi.org/10.1016/j.optlaseng.2020.106010
Allison SW, Gillies GT (1997) Remote thermometry with thermographic phosphors: instrumentation and applications. Rev Sci Instrum 68:2615–2650. https://doi.org/10.1063/1.1148174
Brübach J, Pflitsch C, Dreizler A, Atakan B (2013) On surface temperature measurements with thermographic phosphors: a review. Prog Energy Combust Sci 39:37–60. https://doi.org/10.1016/j.pecs.2012.06.001
Cai T, Kim D, Kim M, Liu YZ, Kim KC (2017) Two-dimensional thermographic phosphor thermometry in a cryogenic environment. Meas Sci Technol. https://doi.org/10.1088/1361-6501/28/1/015201
Cai T, Li Y, Guo S, Peng D, Zhao X, Liu Y (2019) Pressure effect on phosphor thermometry using Mg4FGeO6:Mn. Meas Sci Technol. https://doi.org/10.1088/2053-1583/abe778
Cai T, Park Y, Mohammadshahi S, Kim KC (2020) Rise time-based phosphor thermometry using Mg4FGeO6:Mn4+. Meas Sci Technol. https://doi.org/10.1088/1361-6501/abac8a
Cai T, Deng Z, Park Y, Mohammadshahi S, Liu Y, Chun K (2021) Acquisition of kHz-frequency two-dimensional surface temperature field using phosphor thermometry and proper orthogonal decomposition assisted long short-term memory neural networks. Int J Heat Mass Transf. https://doi.org/10.1016/j.ijheatmasstransfer.2020.120662
Cates MR, Allison SW, Jaiswal SL, Beshears DL (2002) YAG: Dy and YAG: Tm fluorescence above 1400 C under contract DE-AC05–00OR22725. United States Department of Energy, Washington, DC
Feist JP, Heyes AL (2000) The characterization of Y2O2S: Sm powder as a thermographic phosphor for high temperature applications. Meas Sci Technol 11:942–947. https://doi.org/10.1088/0957-0233/11/7/310
Fond B, Abram C, Beyrau F (2015) Characterisation of the luminescence properties of BAM:Eu2+ particles as a tracer for thermographic particle image velocimetry. Appl Phys B Lasers Opt 121:1–15. https://doi.org/10.1007/s00340-015-6261-3
Fuhrmann N, Kissel T, Dreizler A, Brübach J (2011) Gd3Ga5O12: Cr - A phosphor for two-dimensional thermometry in internal combustion engines. Meas Sci Technol. https://doi.org/10.1088/0957-0233/22/4/045301
Ishiwada N, Fujii E, Yokomori T (2018) Evaluation of Dy-doped phosphors (YAG:Dy, Al2O3:Dy, and Y2SiO5:Dy) as thermographic phosphors. J Lumin 196:492–497. https://doi.org/10.1016/j.jlumin.2017.11.045
Jono Y, Suzawa K, Yoshida Y, Yoshida K (2021) Excellent thermal conductive magnesium alloy sheet “SMJ140”, 65–70
Khalid AH, Kontis K (2008) Thermographic phosphors for high temperature measurements: principles, current state of the art and recent applications. Sensors 8:5673–5744. https://doi.org/10.3390/s8095673
Krauss RH, Hellier RG (1994) Surface temperature imaging below 300 K using La2O 2S:Eu. Appl Opt. https://doi.org/10.7868/s0207352814110146
Krauss RH, Hellier RG, McDaniel JC (1994a) Surface temperature imaging below 300 K using La2O2S:Eu. Appl Opt 33:3901–3904. https://doi.org/10.1364/AO.33.003901
Krauss RH, Hellier RG, McDaniel JC (1994b) Surface temperature imaging below 300 K using La_2O_2S:Eu. Appl Opt 33:3901. https://doi.org/10.1364/ao.33.003901
Lee JJ, Dutton JC, Jacobi AM (2007) Application of temperature-sensitive paint for surface temperature measurement in heat transfer enhancement applications. J Mech Sci Technol 21:1253–1262. https://doi.org/10.1007/BF03179042
Mohammadshahi S, Samsam-Khayani H, Cai T, Kim KC (2020) Experimental and numerical study on flow characteristics and heat transfer of an oscillating jet in a channel. Int J Heat Fluid Flow. https://doi.org/10.1016/j.ijheatfluidflow.2008.03.018
Mohammadshahi S, Samsam-Khayani H, Cai T, Nili-Ahmadabadi M, Kim KC (2021) Experimental study on flow characteristics and heat transfer of an oscillating jet in a cross flow. Int J Heat Mass Transf 173:121208. https://doi.org/10.1016/j.ijheatfluidflow.2020.108701
Mohammadshahi S, Samsam-Khayani H, Kim KC (2022) Experimental investigation on flow characteristics of compressible oscillating jet. Phys Fluids 34:16111. https://doi.org/10.1063/5.0076544
Parks JE (2013) Temperature dependent lifetime measurements of fluorescence from a phosphor. Spec. Ed. 2013 AAPT Summer Meet. Work. W36
Samsam-Khayani H, Chen B, Kim M, Kim KC (2022) Visualization of supersonic free jet flow structures subjected to various temperature and pressure ratio conditions. Opt. Lasers Eng. 158:107144. https://doi.org/10.1016/j.optlaseng.2022.107144
Särner G, Richter M, Aldén M (2008) Investigations of blue emitting phosphors for thermometry. Meas Sci Technol. https://doi.org/10.1088/0957-0233/19/12/125304
Srivastava AM, Comanzo HA, Smith DJ, Choi JW, Brik MG, Beers WW, Payne SA (2018) Spectroscopy of Mn4+ in orthorhombic perovskite, LaInO3. J Lumin. https://doi.org/10.1016/j.jlumin.2018.10.090
Steenbakker RJL, Feist JP, Wellman RG, Nicholls JR (2009) Sensor thermal barrier coatings: remote in situ condition monitoring of EB-PVD coatings at elevated temperatures. J Eng Gas Turbines Power 131:1–9. https://doi.org/10.1115/1.3077662
Xu Y, Moon C, Wang JJ, Penyazkov OG, Kim KC (2019) An experimental study on the flow and heat transfer of an impinging synthetic jet. Int J Heat Mass Transf 144:118626. https://doi.org/10.1016/j.ijheatmasstransfer.2019.118626
Yi SJ, Kim M, Kim D, Kim HD, Kim KC (2016) Transient temperature field and heat transfer measurement of oblique jet impingement by thermographic phosphor. Int J Heat Mass Transf 102:691–702. https://doi.org/10.1016/j.ijheatmasstransfer.2016.06.062
Acknowledgements
This work was supported by the National Research Foundation of Korea (NRF) grant, which is funded by the Korean government (MSIT) (No. 2020R1A5A8018822). This work was also supported by the Korea Institute of Energy Technology Evaluation and Planning (KETEP) and the Ministry of Trade, Industry & Energy (MOTIE) of the Republic of Korea (No. 20223030040120).
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
Conflict of interests
The authors declare that they have no known competing financial interests or personal relationships that could have appeared to influence the work reported in this paper.
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
Springer Nature or its licensor (e.g. a society or other partner) holds exclusive rights to this article under a publishing agreement with the author(s) or other rightsholder(s); author self-archiving of the accepted manuscript version of this article is solely governed by the terms of such publishing agreement and applicable law.
About this article
Cite this article
Mohammadshahi, S., Samsam-Khayani, H., Chen, B. et al. Visualization of two-dimensional temperature field on a plate with normal impingement of a supersonic jet. J Vis 26, 841–850 (2023). https://doi.org/10.1007/s12650-022-00907-x
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s12650-022-00907-x