Matrix Inductor With DC-Bias Effect Reduction Capability for GaN-Based DC-DC Boost Converter

Nguyen, Anh Dung; Chen, Cheng-Wei; Lai, Jih-Sheng; Liu, Yu-Chen

doi:10.1109/tcsii.2019.2960759

Title: Matrix Inductor With DC-Bias Effect Reduction Capability for GaN-Based DC-DC Boost Converter

Journal Article · Wed Dec 18 00:00:00 EST 2019 · IEEE Transactions on Circuits and Systems. II, Express Briefs

DOI:https://doi.org/10.1109/tcsii.2019.2960759· OSTI ID:1848747

^[1]; Chen, Cheng-Wei ^[1]; Lai, Jih-Sheng ^[1];

^[2]

Virginia Polytechnic Institute and State University (Virginia Tech), Blacksburg, VA (United States)
National Ilan University, Yilan (Taiwan)

In this brief, a 400-W Gallium Nitride device based DC-DC boost converter with a four phase matrix inductor is proposed. It is well-known that there is a significant influence of the DC bias on inductor core losses and the simplest solution is to employ multiphase structures. However, the size of the converter will also increase as the number of phases increases. Therefore, in order to achieve both high efficiency and high power density, a matrix inductor is proposed for four phases boost converter. The proposed matrix inductor retains the flux sharing advantages of conventional inductors with E-cores and thus greatly increases the power density and utilization rate, by integrating the inductors through flux cancellation. Therefore, both the size and the core loss are reduced when compared with four conventional inductors. Moreover, since the four phases are operated in parallel, the phase error, which is a critical problem in the interleaved structure, may not affect the proposed converter, removing the current balance issue. Critical operation mode is utilized to achieve zero-voltage switching (ZVS) for all switches. Finally, the proposed four phase DC-DC boost converter and matrix inductor is built and tested to verify its feasibility. Here, the peak and CEC efficiency is tested to be 99.3% and 99.1%, respectively.

View Accepted Manuscript (DOE)

Cite

Export

Save

Research Organization:: Virginia Polytechnic Institute and State University (Virginia Tech), Blacksburg, VA (United States); Virginia Polytechnic Inst. and State Univ. (Virginia Tech), Blacksburg, VA (United States)

Sponsoring Organization:: USDOE Office of Energy Efficiency and Renewable Energy (EERE)

Grant/Contract Number:: EE0008347

OSTI ID:: 1848747

Alternate ID(s):: OSTI ID: 2006456

Journal Information:: IEEE Transactions on Circuits and Systems. II, Express Briefs, Vol. 67, Issue 11; ISSN 1549-7747

Publisher:: IEEECopyright Statement

Country of Publication:: United States

Language:: English

References (18)

A Boost Type Resonant Forward Converter With Topology Combination Qian, Ting; Wu, Qichen IEEE Transactions on Circuits and Systems II: Express Briefs, Vol. 65, Issue 12 https://doi.org/10.1109/TCSII.2018.2809444	journal	December 2018
Circuit Design Considerations for Reducing Parasitic Effects on GaN-Based 1-MHz High-Power-Density High-Step-Up/Down Isolated Resonant Converters Zhao, Xiaonan; Chen, Cheng-Wei; Lai, Jih-Sheng IEEE Journal of Emerging and Selected Topics in Power Electronics, Vol. 7, Issue 2 https://doi.org/10.1109/JESTPE.2019.2904288	journal	June 2019
A 98.3% Efficient GaN Isolated Bidirectional DC–DC Converter for DC Microgrid Energy Storage System Applications Xue, Fei; Yu, Ruiyang; Huang, Alex Q. IEEE Transactions on Industrial Electronics, Vol. 64, Issue 11 https://doi.org/10.1109/TIE.2017.2686307	journal	November 2017
Optimal Design of Planar Magnetic Components for a Two-Stage GaN-Based DC–DC Converter Fu, Minfan; Fei, Chao; Yang, Yuchen IEEE Transactions on Power Electronics, Vol. 34, Issue 4 https://doi.org/10.1109/TPEL.2018.2849741	journal	April 2019
High-Efficiency High-Power-Density LLC Converter With an Integrated Planar Matrix Transformer for High-Output Current Applications Fei, Chao; Lee, Fred C.; Li, Qiang IEEE Transactions on Industrial Electronics, Vol. 64, Issue 11 https://doi.org/10.1109/TIE.2017.2674599	journal	November 2017
Interleaved Critical Current Mode Boost PFC Converter With Coupled Inductor Yang, Fei; Ruan, Xinbo; Yang, Yang IEEE Transactions on Power Electronics, Vol. 26, Issue 9 https://doi.org/10.1109/TPEL.2011.2106165	journal	September 2011
Open-Loop Control Methods for Interleaved DCM/CCM Boundary Boost PFC Converters Huber, L.; Irving, B. T.; Jovanovic, M. M. IEEE Transactions on Power Electronics, Vol. 23, Issue 4 https://doi.org/10.1109/TPEL.2008.924611	journal	July 2008
Core Losses Under the DC Bias Condition Based on Steinmetz Parameters Muhlethaler, J.; Biela, J.; Kolar, J. W. IEEE Transactions on Power Electronics, Vol. 27, Issue 2 https://doi.org/10.1109/TPEL.2011.2160971	journal	February 2012
ZVS of Power MOSFETs Revisited Kasper, Matthias; Burkat, Ralph; Deboy, Ferald IEEE Transactions on Power Electronics https://doi.org/10.1109/TPEL.2016.2574998	journal	January 2016
A 10-MHz GaN HEMT DC/DC Boost Converter for Power Amplifier Applications Gamand, Florent; Li, Ming Dong; Gaquiere, Christophe IEEE Transactions on Circuits and Systems II: Express Briefs, Vol. 59, Issue 11 https://doi.org/10.1109/TCSII.2012.2228397	journal	November 2012
Analysis and Implementation of a High Voltage Gain 1 MHz Bidirectional DC–DC Converter Dung, Nguyen Anh; Chiu, Huang-Jen; Liu, Yu-Chen IEEE Transactions on Industrial Electronics, Vol. 67, Issue 2 https://doi.org/10.1109/TIE.2019.2905810	journal	February 2020
Averaged Small-Signal Model of PWM DC-DC Converters in CCM Including Switching Power Loss Ayachit, Agasthya; Kazimierczuk, Marian K. IEEE Transactions on Circuits and Systems II: Express Briefs, Vol. 66, Issue 2 https://doi.org/10.1109/TCSII.2018.2848623	journal	February 2019
High-Frequency High-Efficiency GaN-Based Interleaved CRM Bidirectional Buck/Boost Converter with Inverse Coupled Inductor Huang, Xiucheng; Lee, Fred C.; Li, Qiang IEEE Transactions on Power Electronics, Vol. 31, Issue 6 https://doi.org/10.1109/TPEL.2015.2476482	journal	June 2016
High-Efficiency High-Density Critical Mode Rectifier/Inverter for WBG-Device-Based On-Board Charger Liu, Zhengyang; Li, Bin; Lee, Fred C. IEEE Transactions on Industrial Electronics, Vol. 64, Issue 11 https://doi.org/10.1109/TIE.2017.2716873	journal	November 2017
Design of GaN-Based MHz Totem-Pole PFC Rectifier Liu, Zhengyang; Lee, Fred C.; Li, Qiang IEEE Journal of Emerging and Selected Topics in Power Electronics, Vol. 4, Issue 3 https://doi.org/10.1109/JESTPE.2016.2571299	journal	September 2016
High-Frequency PWM Buck Converters Using GaN-on-SiC HEMTs Rodriguez, Miguel; Zhang, Yuanzhe; Maksimovic, Dragan IEEE Transactions on Power Electronics, Vol. 29, Issue 5 https://doi.org/10.1109/TPEL.2013.2279212	journal	May 2014
A Survey of Wide Bandgap Power Semiconductor Devices Millan, Jose; Godignon, Philippe; Perpina, Xavier IEEE Transactions on Power Electronics, Vol. 29, Issue 5 https://doi.org/10.1109/TPEL.2013.2268900	journal	May 2014
High-Efficiency PFM Boost Converter With an Accurate Zero Current Detector Chen, Hou-Ming; Huang, Hsien-Chi; Jheng, Shih-Han IEEE Transactions on Circuits and Systems II: Express Briefs, Vol. 65, Issue 11 https://doi.org/10.1109/TCSII.2017.2754514	journal	November 2018

Similar Records

Four-phase interleaved TCM DC-DC buck converter with matrix inductor in battery charging application

Journal Article · Wed Dec 30 00:00:00 EST 2020 · IET Power Electronics · OSTI ID:1848747

Nguyen, Anh Dung; Chen, Shu‐Xin; Chen, Yang; +3 more

DC-AC Cascaded H-Bridge Multilevel Boost Inverter With No Inductors for Electric/Hybrid Electric Vehicle Applications

Journal Article · Thu Jan 01 00:00:00 EST 2009 · IEEE Transactions on Industry Applications · OSTI ID:1848747

Tolbert, Leon M; Ozpineci, Burak; Du, Zhong; +1 more

A Novel Inductor-less DC-AC Cascaded H-bridge Multilevel Boost Inverter for Electric/Hybrid Electric Vehicle Applications

Conference · Mon Jan 01 00:00:00 EST 2007 · OSTI ID:1848747

Du, Zhong; Ozpineci, Burak; Tolbert, Leon M; +1 more

Related Subjects

42 ENGINEERING
DC-DC boost converter
magnetic component
high efficiency-high power density converter
critical mode control
14 SOLAR ENERGY

Title: Matrix Inductor With DC-Bias Effect Reduction Capability for GaN-Based DC-DC Boost Converter

Citation Formats

References (18)

Similar Records

Related Subjects